Dell C600 Manual do Utilizador

www.dell.comsupport.dell.comDell™ Latitude™ C600/C500 SeriesSERVICE MANUAL

10 Before You Beginwww.dell.com | support.dell.comPreparing to Work Inside the Computer NOTICE: Only a certified service technician should perform rep

Before You Begin 1113 Handle components and cards with care. Do not touch the components or contacts on a card. Hold a card by it edges or by its meta

12 Before You Beginwww.dell.com | support.dell.comScrew IdentificationWhen you are removing and replacing components, photocopy the placemat as a tool

Before You Begin 13Display Assembly Bezel: (6 each)Rubber Screw Covers (6 each)Display Assembly Hinge Bracket to Bottom Case Assembly:

14 Before You Beginwww.dell.com | support.dell.comSystem Board to Bottom Case Assembly: (10 each)Display Panel to Support Bracket: (12.1-in

www.dell.com | support.dell.comSECTION 2Removing and Replacing PartsComponentsHard DriveMemory ModuleMini-PCI Card AssemblyKeyboard AssemblyRemoving t

16 Removing and Replacing Partswww.dell.com | support.dell.comComponentsExploded View NOTICE: Only a certified service technician should perform repai

Removing and Replacing Parts 17Hard Drive NOTICE: The hard drive is very sensitive to shock. Handle the assembly by its edges (do not squeeze the top

18 Removing and Replacing Partswww.dell.com | support.dell.com2 Push down on the drive door until it snaps into place.3 Replace the M3 x 5-mm screw in

Removing and Replacing Parts 19 NOTE: The screw labeled with the "circle K" in the middle of the memory module cover secures the keyboard as

20 Removing and Replacing Partswww.dell.com | support.dell.com NOTICE: Read "Preparing to Work Inside the Computer" before performing the fo

Removing and Replacing Parts 21Mini-PCI Card Assembly Using Interface CablesMini PCI Wireless NIC Assembly Using Antenna Cablemodem connectorNIC conne

22 Removing and Replacing Partswww.dell.com | support.dell.comRemoving the Mini-PCI Card Assembly NOTICE: Disconnect the computer and any attached dev

Removing and Replacing Parts 23Keyboard AssemblyRemoving the Keyboard ScrewsRemoving the Keyboard Assembly NOTICE: Disconnect the computer and any att

24 Removing and Replacing Partswww.dell.com | support.dell.com4 To release the keyboard from the palmrest assembly, use a small, flat-blade screwdrive

Removing and Replacing Parts 25Keyboard Connector8 Disconnect the keyboard flex cable from the interface connector on the system board assembly by pul

26 Removing and Replacing Partswww.dell.com | support.dell.com NOTICE: Position the keyboard flex cable so it is not pinched when you replace the keyb

Removing and Replacing Parts 27Display Assembly1Remove the hard drive.2 Remove the center control cover.a Use a scribe to lift the right edge of the c

28 Removing and Replacing Partswww.dell.com | support.dell.com4 From the back of the computer, remove the five M2.5 x 5-mm screws labeled with the &qu

Removing and Replacing Parts 2914.1-Inch Display Assembly Bezel and Paneldisplay paneldisplay-assembly top coverM2.5 x 5-mm screws (6)rubber screw cov

www.dell.comsupport.dell.comDell™ Latitude™ C600/C500 SeriesSERVICE MANUAL

30 Removing and Replacing Partswww.dell.com | support.dell.comRemoving the 14.1-Inch Display Assembly Bezel NOTICE: Disconnect the computer and any at

Removing and Replacing Parts 316 Remove the M2 x 4-mm screw that secures the display-feed flex cable to the display assembly through the black plastic

32 Removing and Replacing Partswww.dell.com | support.dell.comRemoving the Display-Feed Flex Cable (14.1-Inch Display Panel)Display-Feed Flex Cable NO

Removing and Replacing Parts 3312.1-Inch Display Assembly Bezel and Paneldisplay assembly bezelrubber screw covers (6)M2.5 x 5-mm screws (6)display-as

34 Removing and Replacing Partswww.dell.com | support.dell.comRemoving the 12.1-Inch Display Assembly Bezel NOTICE: Disconnect the computer and any at

Removing and Replacing Parts 357 Lift up the right side of the display panel, and pull the panel out of the display-assembly top cover at an angle.Rep

36 Removing and Replacing Partswww.dell.com | support.dell.comRemoving the Display-Feed Flex Cable (12.1-Inch Display Panel)Display-Feed Flex Cable NO

Removing and Replacing Parts 376 Disconnect the bottom flex cable connector from the inverter connector by pulling straight up on the attached pull ta

38 Removing and Replacing Partswww.dell.com | support.dell.com4 Remove the display assembly latch by removing the two M2.5 x 5-mm screws that secure i

Removing and Replacing Parts 39 Hinge CoversRemoving the Hinge CoversRemoving the Hinge Covers1 Remove the display assembly.2 Rotate the hinges forwar

Notes, Notices, and Cautions NOTE: A NOTE indicates important information that helps you make better use of your computer. NOTICE: A NOTICE indicates

40 Removing and Replacing Partswww.dell.com | support.dell.comReplacing the Hinge CoversHinge Covers1Attach the display assembly to the bottom case as

Removing and Replacing Parts 412 Close the display assembly and snap the hinge covers in place over the hinges. NOTE: The right plastic hinge cover la

42 Removing and Replacing Partswww.dell.com | support.dell.com NOTICE: Read "Preparing to Work Inside the Computer" before performing the fo

Removing and Replacing Parts 43Palmrest Assembly8 Using the plastic scribe along the edge of the plastic, remove the palmrest assembly from the bottom

44 Removing and Replacing Partswww.dell.com | support.dell.comMicroprocessor Thermal Cooling AssemblyMicroprocessor Thermal Cooling AssemblyRemoving t

Removing and Replacing Parts 453 Turn the computer over, lift the keyboard up, rotate it forward toward the front of the computer, and place it face d

46 Removing and Replacing Partswww.dell.com | support.dell.comRemoving the Hybrid Cooling Fan1 Remove the hard drive.2 Remove the keyboard assembly.3

Removing and Replacing Parts 47Microprocessor ModuleMicroprocessor Modules NOTICE: Hold the microprocessor down while turning the cam screw to prevent

48 Removing and Replacing Partswww.dell.com | support.dell.com3 Remove the microprocessor thermal cooling assembly. NOTICE: When removing the micropro

Removing and Replacing Parts 493 Update the BIOS using a flash BIOS update program diskette or CD. NOTE: For instructions to update or flash the BIOS,

Contents 5Contents1 Before You BeginPreparing to Work Inside the Computer . . . . . . . . . . . . . . 10Recommended Tools . . . . . . . . . . . . . .

50 Removing and Replacing Partswww.dell.com | support.dell.com1 Remove the hard drive.2 Remove the memory module cover.3 Disconnect the reserve batter

Removing and Replacing Parts 51Routing the Left Speaker CableRemoving the Speaker Assemblies NOTICE: Disconnect the computer and any attached devices

52 Removing and Replacing Partswww.dell.com | support.dell.comSpeaker Assembliesin-line connectorleft speakerright speakerright speaker holderleft spe

Removing and Replacing Parts 531 Remove the hard drive.2 Remove the keyboard assembly.3 Remove the display assembly.4 Remove the palmrest assembly.5 D

54 Removing and Replacing Partswww.dell.com | support.dell.comRemoving the System Board Assembly ScrewsRemoving the System Board NOTICE: Disconnect th

Removing and Replacing Parts 558 Verify that the PC Card ejectors do not extend from the PC Card slot.9 Turn the computer over, and remove the six M2.

56 Removing and Replacing Partswww.dell.com | support.dell.com13 Pull the right side of bottom case assembly, next to the external headphone and micro

Removing and Replacing Parts 57Battery and Modular Bay Latch AssembliesBattery and Modular Bay Latch AssembliesRemoving the Battery and Modular Bay La

58 Removing and Replacing Partswww.dell.com | support.dell.com NOTICE: Read "Preparing to Work Inside the Computer" before performing the fo

Index 59IndexBbattery and modular bay latch assembliesremoving, 57Ddisplay assemblyremoving, 26display assembly bezelremoving, 29, 33display assembly

Contents 6Replacing the 14.1-Inch Display Panel . . . . . . . . . . . . . 31Removing the Display-Feed Flex Cable (14.1-Inch Display Panel) 32Remov

60 Index60 Indexsystem boardremoving, 54replacing, 56system board assemblyremoving, 47system components, 16Tthermal cooling assemblyremoving, 44

082EWX A01www.dell.comsupport.dell.comPrinted in the U.S.A.P/N 82EWX Rev. A01

Contents 7Battery and Modular Bay Latch Assemblies . . . . . . . . . . . . 57Removing the Battery and Modular Bay Latch Assemblies. . . . 57Index .

8 Contents

www.dell.com | support.dell.comSECTION 1Before You BeginPreparing to Work Inside the ComputerRecommended ToolsScrew Identification